Home > Notice of Letting > Contract Detail

December 13, 2024 Letting 12:00 PM
003-62T30

Plans and Special Provisions
Pay Item Report
Electronic Bidding (EBids)

Bulletin Description

(307-Ft) Bridge preservation project: Deck overlay, Joints replacement/repair. Located on IL 53 / Rohlwing Road, at Canadian National (CN) Railroad (approximately 0.1-miles South of Fullerton Avenue) in the Village of Addison.
Region District DBE % VBP % Federal Project #
1 1 0.00 0.00 NHPPJSQ5(268)
County(s) Key Route(s) Marked Route(s) Section(s) State Job #(s) PPS #(s)
  • DuPage
  • FAP 870
  • IL 53 (ROHLWING RD)
  • FAP 0870 22 BJ
  • C-91-335-22
  • 1-81105-0000
Contract Specifics
60 Working Days
Previously advertised on November 08, 2024 (Item 016).
No More Contract Specifics

Ask Subscribe Questions and Answers (5 Submitted / 4 Answered ) Questions not accepted as of December 03, 2024 04:30 PM.

  • Ref: Deck Latex Overlay, Const Req'ts,(a)(1) P-2. REQUIRES the use of mech scarification, yet if the "...use of mech scarifying equip results in exposing, snagging, or dislodging the top mat of rebar,.." then "All damage to the existing rebar resulting from the Contractor’s operation shall be repaired or replaced at the Contractor’s expense ..". You are requiring us to use a specific method, yet if damage occurs repair it at our cost. Then why can we not use hydro-scarification for all removal?
    The SP section referenced is for the initial ¼”. After ¼” of mechanical scarification, hydroscarification may be used. (11/21/2024)

  • Where is the Earth Excavation located?
    Earth excavation is located at 1. South slopewall 2. NW, NE, SW, SE sidewalks 3. North median (11/21/2024)

  • What is the length of the pipes below the floor drains, or specifically the scuppers, assumed to be Drainage Structure to be cleaned (and adjusted)?
    This pay item is an EACH unit. Please refer to the specs. (11/21/2024)

  • Where are the locations for these items to be cleaned? X5537800 - Sewers to be cleaned. Z0018500 - Drainage structures to be cleaned. And where are the Drainage Scuppers to be Adjusted? Is the Section Thru Floor Drains on sheet 22 supposed to be these? The details look as if the scupper/floor drain is to remain as-is and the overlay is to slope and overlap the scupper. This item is not included with the page's BOM.
    Sewers to be cleaned are estimated to be 15’ for the 4 catch basins adjacent to the bridge. Drainage structures to be cleaned are the 4 catch basins adjacent to the bridge at each quadrant. Drainage Scuppers to be Adjusted ill be addressed in an addendum. Contractors should monitor the website for the addendum. (11/20/2024)

Authorized Bidders

  • 2166 Granite Construction Company
    585 West Beach Street
    Watsonville, CA 95076
    2215 Sanders Road
    Suite 400
    Northbrook, IL 60062
    Phone: (847) 919-8200 Fax: (847) 272-5930 Email: gmcivilestimating@gcinc.com

  • 3505 Lorig Construction Company
    250 East Touhy Avenue
    Des Plaines, IL 60018
    Phone: (847) 298-0360 Fax: (847) 298-2689 Email: estimating@lorigconstruction.com

Non Bidders

  • 0103 Alliance Contractors, Inc.
    (Pending Authorization)
    1166 Lake Avenue
    Woodstock, IL 60098
    Phone: (815) 338-5900 Fax: (815) 338-9109 Email: estimating@alliancecontractors.com

  • 0204 Areatha Construction Co., Inc.
    (Pending Authorization)
    410 E. North Avenue
    Streamwood, IL 60107
    Phone: (630) 830-9853 Fax: (630) 830-9856 Email: areathaconstco@sbcglobal.net

  • 1552 Dunnet Bay Construction Company
    (Pending Authorization)
    115 N. Brandon Drive
    Glendale Heights, IL 60139
    Phone: (630) 539-1200 Fax: (630) 539-4171 Email: estimating@dunnetbay.net

  • 3574 MYS, Incorporated
    (Pending Authorization)
    12416 S. Harlem Ave
    Palos Heights, IL 60463
    Phone: (708) 448-0983 Fax: (708) 448-8098 Email: tyelnick@mysincorporated.com

  • 1560 R. W. DUNTEMAN COMPANY
    600 S. LOMBARD RD.
    ADDISON, IL 60101
    P. O. BOX 1129
    ADDISON, IL 60101
    Phone: (630) 953-1500 Fax: (630) 932-0994 Email: estimating@rwdco.com

Pay Item # UOM Description Type Quantity Unit Price
20200100 CU YD EARTH EXCAVATION Base items 15.000
40600290 POUND BITUMINOUS MATERIALS (TACK COAT) Base items 418.000
40600985 SQ YD PORTLAND CEMENT CONCRETE SURFACE REMOVAL - BUTT JOINT Base items 430.000
40604172 TON POLYMERIZED HOT-MIX ASPHALT SURFACE COURSE, IL-9.5, MIX "E", N70 Base items 87.000
42400200 SQ FT PORTLAND CEMENT CONCRETE SIDEWALK 5 INCH Base items 185.000
44000100 SQ YD PAVEMENT REMOVAL Base items 287.000
44000600 SQ FT SIDEWALK REMOVAL Base items 185.000
44003100 SQ FT MEDIAN REMOVAL Base items 1,719.000
50102400 CU YD CONCRETE REMOVAL Base items 53.000
50157300 SQ YD PROTECTIVE SHIELD Base items 380.000
50300255 CU YD CONCRETE SUPERSTRUCTURE Base items 60.000
50300300 SQ YD PROTECTIVE COAT Base items 1,706.000
50500405 POUND FURNISHING AND ERECTING STRUCTURAL STEEL Base items 8,800.000
50800205 POUND REINFORCEMENT BARS, EPOXY COATED Base items 7,070.000
50800515 EACH BAR SPLICERS Base items 112.000
52000110 FOOT PREFORMED JOINT STRIP SEAL Base items 318.000
59300100 CU YD CONTROLLED LOW-STRENGTH MATERIAL Base items 15.000
60618300 SQ FT CONCRETE MEDIAN SURFACE, 4 INCH Base items 1,719.000
66900200 CU YD NON-SPECIAL WASTE DISPOSAL Base items 15.000
66900530 EACH SOIL DISPOSAL ANALYSIS Base items 1.000
66901001 L SUM REGULATED SUBSTANCES PRE-CONSTRUCTION PLAN Base items 1.000
66901003 L SUM REGULATED SUBSTANCES FINAL CONSTRUCTION REPORT Base items 1.000
66901006 CAL DA REGULATED SUBSTANCES MONITORING Base items 1.000
67100100 L SUM MOBILIZATION Base items 1.000
70107025 CAL DA CHANGEABLE MESSAGE SIGN Base items 220.000
70300150 SQ FT SHORT TERM PAVEMENT MARKING REMOVAL Base items 2,390.000
70307100 SQ FT TEMPORARY PAVEMENT MARKING LETTERS AND SYMBOLS - TYPE IV TAPE Base items 111.000
70307120 FOOT TEMPORARY PAVEMENT MARKING - LINE 4" - TYPE IV TAPE Base items 5,870.000
70307130 FOOT TEMPORARY PAVEMENT MARKING - LINE 6" - TYPE IV TAPE Base items 593.000
70307160 FOOT TEMPORARY PAVEMENT MARKING - LINE 12"- TYPE IV TAPE Base items 27.000
70400100 FOOT TEMPORARY CONCRETE BARRIER Base items 800.000
70400200 FOOT RELOCATE TEMPORARY CONCRETE BARRIER Base items 800.000
70600240 EACH IMPACT ATTENUATORS, TEMPORARY (NON- REDIRECTIVE), TEST LEVEL 2 Base items 2.000
70600340 EACH IMPACT ATTENUATORS, RELOCATE (NON- REDIRECTIVE), TEST LEVEL 2 Base items 2.000
72000100 SQ FT SIGN PANEL - TYPE 1 Base items 7.500
72400100 EACH REMOVE SIGN PANEL ASSEMBLY - TYPE A Base items 1.000
72800100 FOOT TELESCOPING STEEL SIGN SUPPORT Base items 13.500
78004635 FOOT PREFORMED PLASTIC PAVEMENT MARKING, TYPE D - STANDARD - LINE 7" Base items 594.000
78009000 SQ FT MODIFIED URETHANE PAVEMENT MARKING - LETTERS AND SYMBOLS Base items 204.000
78009004 FOOT MODIFIED URETHANE PAVEMENT MARKING - LINE 4" Base items 4,138.000
78009006 FOOT MODIFIED URETHANE PAVEMENT MARKING - LINE 6" Base items 526.000
78009008 FOOT MODIFIED URETHANE PAVEMENT MARKING - LINE 8" Base items 437.000
78009012 FOOT MODIFIED URETHANE PAVEMENT MARKING - LINE 12" Base items 153.000
78009024 FOOT MODIFIED URETHANE PAVEMENT MARKING - LINE 24" Base items 56.000
78011040 FOOT GROOVING FOR RECESSED PAVEMENT MARKING 8" Base items 594.000
78100100 EACH RAISED REFLECTIVE PAVEMENT MARKER Base items 4.000
78300200 EACH RAISED REFLECTIVE PAVEMENT MARKER REMOVAL Base items 4.000
78300202 SQ FT PAVEMENT MARKING REMOVAL - WATER BLASTING Base items 1,860.000
K1004595 L SUM PRUNING FOR SAFETY AND EQUIPMENT CLEARANCE Base items 1.000
X0300062 SQ YD GRAFFITI REMOVAL Base items 5.000
X2010516 UNIT SELECTIVE CLEARING Base items 0.030
X4400503 FOOT COMBINATION CURB AND GUTTER REMOVAL AND REPLACEMENT GREATER THAN 10 FEET Base items 708.000
X5030250 SQ YD BRIDGE DECK GROOVING (LONGITUDINAL) Base items 960.000
X5030539 EACH FLOOR DRAINS TO BE CLEANED Base items 12.000
X5537800 FOOT STORM SEWERS TO BE CLEANED 12" Base items 60.000
X6700407 CAL MO ENGINEER'S FIELD OFFICE, TYPE A (D1) Base items 12.000
X7010216 L SUM TRAFFIC CONTROL AND PROTECTION, (SPECIAL) Base items 1.000
X7830050 EACH RAISED REFLECTIVE PAVEMENT MARKER, REFLECTOR REMOVAL Base items 110.000
X7830052 EACH RAISED REFLECTIVE PAVEMENT MARKER, REFLECTOR REPLACEMENT Base items 110.000
Z0001700 SQ YD APPROACH SLAB REPAIR (FULL DEPTH) Base items 17.000
Z0001800 SQ YD APPROACH SLAB REPAIR (PARTIAL DEPTH) Base items 28.000
Z0001903 POUND STRUCTURAL STEEL REMOVAL Base items 8,800.000
Z0005216 SQ YD HOT-MIX ASPHALT STABILIZATION 6" AT STEEL PLATE BEAM GUARD RAIL Base items 49.000
Z0006016 SQ YD BRIDGE DECK LATEX CONCRETE OVERLAY, 2 3/4 INCHES Base items 1,115.000
Z0007122 FOOT REMOVING AND RE-ERECTING EXISTING RAILING Base items 78.000
Z0012130 SQ YD BRIDGE DECK SCARIFICATION 3/4" Base items 1,115.000
Z0012754 SQ FT STRUCTURAL REPAIR OF CONCRETE (DEPTH EQUAL TO OR LESS THAN 5 INCHES) Base items 396.000
Z0016002 SQ YD DECK SLAB REPAIR (FULL DEPTH, TYPE II) Base items 1.000
Z0018051 EACH DRAINAGE SCUPPERS TO BE ADJUSTED Base items 4.000
Z0018500 EACH DRAINAGE STRUCTURES TO BE CLEANED Base items 4.000
Z0029090 SQ YD DIAMOND GRINDING (BRIDGE SECTION) Base items 1,216.000
Z0030850 SQ FT TEMPORARY INFORMATION SIGNING Base items 62.000
Z0048665 L SUM RAILROAD PROTECTIVE LIABILITY INSURANCE Base items 1.000
Z0062456 SQ YD TEMPORARY PAVEMENT Base items 287.000
Z0065700 SQ YD SLOPE WALL REPAIR Base items 87.000
Z0073200 EACH TEMPORARY SHORING AND CRIBBING Base items 13.000
Z0073510 EACH TEMPORARY TRAFFIC SIGNAL TIMING Base items 1.000
No More Pay Items

The contract details above are for informational purposes only until the Plans and Special Provisions are posted on this web page. If an addendum is posted, the contract details above may be revised. Please continue to check for addenda.